Jeep yj fuel return line.

Return line at 0psi so that looks clear. Checked temp sensor and ohm readings go down when warm. Map sensor checks OK. Grounds and voltage to the ECM is good. New coil and timing set at 8 BTDC Vacuum lines are all new and confirmed correctly hooked up. When I installed the used kit I used new O2, Coolant sensor, and fuel filter.Operating Pressure: 17 PSI. Minimum Flow @ Outlet: 28 GPH Low Pressure. Fuel Pump Location: In-Tank. The motor Im running is a 4.3 and heres is the stoc specs for that fuel pump. S10 pump=. Walbro Part Number: 5CA401. Minimum Current: 12 Volts. Operating Pressure: 12 PSI. Minimum Flow @ Outlet: 29 GPH Low Pressure.YJ Fuel Line - Rubber hose section. 89 YJ 4.2L. Leaking fuel line and not sure what size or how to get the clamps off to replace the line. There are 2 short hoses that are on the driver side engine, one goes from the metal fuel line to the filter and the other line goes to the mech fuel pump on the passenger side.640 subscribers. Subscribed. 33. 5.5K views 2 years ago. Replacing original fuel lines at gas tank on a 1995 Jeep Wrangler YJ. Produced with CyberLink PowerDirector 20 …Feb 12, 2020 · Only one pressure line, other two are evap lines I think. fuel return will be added after I add the novak kit. O. ol rob. 68 posts · Joined 2019. #3 · Feb 13, 2020. I ran a 6AN pressure line from the LS regulator to the engine and completely removed all of the Jeep fuel system. I also made the short return like Novak suggests.

The Jeep power train control module (PCM)--or computer, as it is known in layman’s terms--controls the vehicle’s ignition, emission and fuel systems, along with other auxiliary sys...13 Mar 2013 ... Do any of you have a good picture of a return line setup on an amc v8? Is it 1/4"? Is it rubber all the way from filter to tank?

Jeeps, we have them ... Working on the gas tank on our 81'. I know it's fed up the passenger side to the pump on this and my CJ7'. I have a return ...Ok, trying to determine how to run my fuel line from the filter to back of the jeep. Suggestions welcome. I bent up these new 3/8" stainless lines to follow the factory fuel routing. This is for an early GM 5.3 with a return line. Red line, follows the factory pattern, but will need a 90* fitting... Blue line, nice and straight, but behind the ...

The hose that connect where the fuel pressure regulator is the return line. It acts like a plug that stops return if pressure is too low. '91 YJ Sahara 4.0L/AX-15/NP231, D30/D35 @3.07All my fuel lines are custom. I took the metal lines off the intake manifold to replace the soft portion between them and the frame since it was dry rotted, and forgot to mark them. So Now I dont know which one on the fuel rail is the feed line... the one with the regulator in front of it.. or the other.Feb 12, 2020 · Only one pressure line, other two are evap lines I think. fuel return will be added after I add the novak kit. O. ol rob. 68 posts · Joined 2019. #3 · Feb 13, 2020. I ran a 6AN pressure line from the LS regulator to the engine and completely removed all of the Jeep fuel system. I also made the short return like Novak suggests. I have decided to head down the path of replacing the exhaust manifold myself on my 1992 4.0L YJ. All was going smooth until I tried to disconnect the supply side fuel line from the fuel rail. The line that returns to the tank disconnected without any tools no problem. Anyone had any trouble...Sep 12, 2012 · 12K views 2 replies 2 participants last post by Que89YJ Sep 13, 2012. V. vinny147 Discussion starter. 129 posts · Joined 2012. #1 · Sep 12, 2012. Does anyone know what size the fuel line going into the fuel filter is? That's the line coming from the fuel tank. I can't seem to find it. Sort by Oldest first.

Wingman remote not working

34. 34202728. CLIP. Genuine Mopar Parts, the Right Choice. MoparPartsGiant .com offers the wholesale prices for genuine 1990 Jeep Wrangler parts. Parts like Fuel Lines are shipped directly from authorized Mopar dealers and backed by the manufacturer's warranty. Parts fit for the following vehicle options. Engine: 4 Cyl 2.5L, 6 Cyl 4.2L.

Operating Pressure: 17 PSI. Minimum Flow @ Outlet: 28 GPH Low Pressure. Fuel Pump Location: In-Tank. The motor Im running is a 4.3 and heres is the stoc specs for that fuel pump. S10 pump=. Walbro Part Number: 5CA401. Minimum Current: 12 Volts. Operating Pressure: 12 PSI. Minimum Flow @ Outlet: 29 GPH Low Pressure.dodger889. 4184 posts · Joined 2009. #2 · Nov 30, 2010. Large one is 5/16 and the return is 1/4. But the 5/16 will supply enough to run a 350 tbi. A 89 yj with a 4.0 aw4 sye out of an 92xj. Now the hard part is done time to get it up in the air just a bit. Working on 8.8 with 3.73 and lsd for the rear. and new D30 hp with 3.73 .Apr 26, 2014 · My thought is the feed will go to the fuel pump then to the larger output line from the fuel pump. Anyone have a picture of the fuel pump lines. Follow the line to the fuel filter. If it hooks to the filter, it is your pressure line (feed), if not, it is the return. 418 miles on 19 gallons of gas. Become a Distributor. Click on image to zoom. 1994 Jeep Wrangler YJ Fuel Tank to Fuel Pump Line. Fuel Feed Line. (0) Reviews: Write firstreview. New. SKU: JEF1015-SS. USD79.99. Pricing: $79.99.20314 posts · Joined 2014. #2 · Mar 22, 2017. Why bother! The mechanical pump you currently have has worked well on a multitude of Jeeps and AMC and Mopar vehicles. The reason the manufacturer went to an electric pump was because of fuel injection. The mechanical pump is easy to change if it fails, which it seldom does.

1417 posts · Joined 2007. #6 · Oct 29, 2009. If you ever plan on fuel injecting this engine this would be the time to upgrade the fuel line diameters and go ahead and use some adaptors to connect the flex lines. The 1/4 inch diameter return line is just to small for fuel injection. OMIX Fuel Line Return Line for 76-83 Jeep CJ-7 with 3.8/4.2L ... OMIX Front Fuel Supply Line for 94-98 Jeep Cherokee XJ, Grand Cherokee ZJ & Wrangler YJ with 4.0L ... Find jeep tj 03-04 wrangler Opr jeep wrangler stainless steel fuel return line j110287 (1994 jeep Fuel line wrangler jeep sahara Replace jeepforum yj. Repair Workshop ... 1994 wrangler yj return opr. Fuel jeep line wrangler cyl tj 2040 partsFuel jeep cherokee grand lines 1997 line diagram front tube mopar engine fullsize retainer supply ...MoparPartsGiant.com offers genuine Fuel Lines for 1990 Jeep Wrangler with great price and fast delivery. ... (1 of 1): FUEL FUEL LINES U.S., CANADA AND ECE WRANGLER, YJ. Enlarge Diagram. Sort by: Ref No. Ref No. Part No. & Part Description. ... Fuel Return - 2.5L Eng. 7. 83502745 REPAIR PACKAGE - 2.5L Eng. Require Quantity: 2.The high ethanol content of fuel these days can melt fuel lines and corrode and crack the fuel pipes on top of the tank '91 YJ Sahara 4.0L/AX-15/NP231, D30/D35 @3.07 '12 KK Cherokee 3.7L/42RLE/MP1522,D30M/[email protected] Guaranteed No hassle return policy; ... Crown Automotive Fuel Sending Unit and Fuel Pump for 87-90 Jeep Wrangler YJ with 2.5L 4 Cylinder Engine & 15 Gallon Fuel Tank. ... will not fit into the fuel line connector on my 1995 Cherokee XJ. Submit your own Review; Questions. Eli S. 2/28/2020.Nov 16, 2018 · Heated them with a heat gun to bend them to shape and install the new Dorman quick disconnects. The pressure line has a 5/16” quick disconnect and the return is an odd 3/8” quick disconnect that steps down to a 5/16” line. The rubber lines were replaced with 5/16” fuel injection hose and fuel injection clamps.

MoparPartsGiant.com offers genuine Fuel Line for 1993 Jeep Wrangler with great price and fast delivery. ... FUEL FUEL LINES - REAR WRANGLER, YJ. Sort by: Ref No. Ref No. Part No. & Part Description. Price. ... Fuel Return w/Quick Connect. 2.5L Eng. 1991. Fitting Vehicle Options: YJ. 2.Sep 21, 2010 · If you suspect that the fuel return line is blocked, a simple test to do would be to remove the fuel return line and blow through it. If you can do this, then it is not blocked. Another test you can do is to put a fuel pressure gauge in the return line, run the engine through idle to about 1500 RPMs, and see what it reads.

A Jeep YJ fuel line diagram simplifies this intricate design, providing visual clarity and aiding in easier component identification. Consider the Jeep YJ fuel line diagram as a navigational map on a road journey — It plots the path from your fuel tank (“home base”) leading up to the engine (“destination”), marking significant ...Hi Moses, Ironically the first thing I did was to replace the fuel filter, assuming that it was restricted to the carburetor. After finding the gas tank vent line clogged I deducted that all the extra pressure from gasoline vapors was traveling backwards to the filter throught the return line, then the vapor lock occurred.I just got my '89 YJ if the mechanical fuel pump compensates for too much pressure downstream. He also broke the fuel fill vent, so I'm replacing the tank, and thus all fuel lines - will restore it to normal config with fuel supply and return lines and vent line to cannister unless someone knows that a return line is not really needed.MikeyinaYJ. 255 posts · Joined 2014. #2 · Jul 23, 2014. You could remove it and blow air through it or test fuel pressure, should be a high reading if blocked around 70 I believe. ----------------------------------------. 1994 jeep wrangler 2.5l. Like.The fuel return line maintains the fuel pressure by returning excess fuel to the fuel tank, preventing a fuel pressure buildup and ensuring that fuel reaches the …yj fuel line replacement. 08-07-2006, 10:48 PM. The rubber fuel line from the tank to the hard line on the frame is leaking on my YJ. It is a 93 and i was wondering if anybody knows the size of the 2 lines (feed-return) and if i need any special tools or if they are just clamps to replace them. Would just like to have everything in hand to make ...Only one pressure line, other two are evap lines I think. fuel return will be added after I add the novak kit. O. ol rob. 68 posts · Joined 2019. #3 · Feb 13, 2020. I ran a 6AN pressure line from the LS regulator to the engine and completely removed all of the Jeep fuel system. I also made the short return like Novak suggests.Replacing fuel check-valve on Wrangler. My wrangler doesn't start on the first try anymore. I turn the key and it just cranks. I wait a second and boom, it starts right up. It was suggested that my fuel check valve has gone bad and needs to be replaced. As far as I can tell, that check valve is in the top of the gas tank.The fuel line system in a Jeep YJ consists of various components, including fuel lines, fuel filters, and fuel pumps, which all work together to supply the engine with the necessary fuel. One of the key functions of the fuel line system in a Jeep YJ is to maintain proper fuel pressure. The fuel pump, located inside the fuel tank, pumps fuel ...

Buncombe county prison

Operating Pressure: 17 PSI. Minimum Flow @ Outlet: 28 GPH Low Pressure. Fuel Pump Location: In-Tank. The motor Im running is a 4.3 and heres is the stoc specs for that fuel pump. S10 pump=. Walbro Part Number: 5CA401. Minimum Current: 12 Volts. Operating Pressure: 12 PSI. Minimum Flow @ Outlet: 29 GPH Low Pressure.

Jeep YJ Fuel System for Wrangler (1987-1995) OPR Stainless Steel Fuel Supply Line (1994 Jeep Wrangler YJ) Item J110288. Save. Verify parts fit and get product …Heated them with a heat gun to bend them to shape and install the new Dorman quick disconnects. The pressure line has a 5/16" quick disconnect and the return is an odd 3/8" quick disconnect that steps down to a 5/16" line. The rubber lines were replaced with 5/16" fuel injection hose and fuel injection clamps.The second vent line should run to the "out" side of the fuel filter. Your fuel filter should have two ports on one side of it; one goes to the carb and the other to the vent on the gas tank. This lets the psi above the recommended 4psi (I think) run back into the gas tank so that line is not really a vent but a return line from the fuel filter.Nov 16, 2018 · Heated them with a heat gun to bend them to shape and install the new Dorman quick disconnects. The pressure line has a 5/16” quick disconnect and the return is an odd 3/8” quick disconnect that steps down to a 5/16” line. The rubber lines were replaced with 5/16” fuel injection hose and fuel injection clamps. Shop Jeep Wrangler Fuel System. Hand-picked by experts! Pay later or over time with Affirm. ... Fuel Lines and Hoses 169; Fuel Injectors 52; Fuel Pumps 52; Fuel Filters 18; ... Fuel Filter (87-90 4.2L Jeep Wrangler YJ w/ 20 Gallon Tank) $14.99 (8) Fuel Filter; Sending Unit Filter (70-86 Jeep CJ5 & CJ7) $20.99.Nov 6, 2019. #3. The clip at the lower side of the steel line bolts to the block low down. The steel tube runs up and over the intake then uses a hose to connect to the fuel filter. The long hose in your pic then connects to the steel return line to the tank. The FSM for 84-86 CJ's is on line in a few places, won't have pics, but will have ...2654 posts · Joined 2017. #5 · Oct 14, 2017. WRONG after 95 or 96 there is only one fuel line and regulator in tank not on rail, supply only no return line. All TJ and 97-01 XJ only one fuel line. 91-95 YJ and XJ 4.0 two lines, supply and return and regulator on front of rail. Not sure on 96 XJ as it was a transition year and there ain’t no ...yj fuel line replacement. 08-07-2006, 10:48 PM. The rubber fuel line from the tank to the hard line on the frame is leaking on my YJ. It is a 93 and i was wondering if anybody knows the size of the 2 lines (feed-return) and if i need any special tools or if they are just clamps to replace them. Would just like to have everything in hand to make ...137 posts · Joined 2013. #1 · Apr 15, 2014. Have been chasing a P0442 code and have changed out any suspect rubber lines and added hose clamps where needed as well as replacing the gas cap. I have noticed that my very rusty fuel vapor return line looks to have a few small seeps, showing wet spots on the line in the same consistent places.Fuel-efficient vehicles are becoming more and more common. Check out these great articles about fuel-efficient vehicles from HowStuffWorks. Advertisement Fuel-efficient vehicles ar...

1417 posts · Joined 2007. #6 · Oct 29, 2009. If you ever plan on fuel injecting this engine this would be the time to upgrade the fuel line diameters and go ahead and use some adaptors to connect the flex lines. The 1/4 inch diameter return line is just to small for fuel injection.YJ-XJ Fuel Lines. I have an 89 YJ (had a 4.2) and have installed 4.0 from a 90 XJ. Kept the original Peugeot manual tranny. Got a lot of obstacles to overcome (mainly wiring-don't have the donor XJ bulkhead harness) and the one that I am working on right now is the fuel delivery. I am trying to figure out how to tie the YJ fuel lines (4th ...The return line also should be on the top side of the filter, above the carb line to prevent gas siphoning back to the tank when it sits, making for long cold starts. Mike 86/00 CJ7 Laredo, 33x9.5 BFG AT's, 'glass nose to tail in '00, 'New' frame,wires and plumbing in '09.Tweet. #3. 03-04-2010, 12:17 PM. i just did a frame off on a 78 cj5 last season and if i remember correcty there are 3 nozzles on the tank on the front drivers side. one for fuel delivery to the filter. one is the return line and i think the third was an emission but mine was disconnected and plugged. yours being 75 might not have the third one ...Instagram:https://instagram. wsyx tv #1 · Aug 1, 2017. I have a 1991 Jeep Wrangler, 4.0. I need to know how to remove the quick disconnect fuel return line off the manifold. There is a tiny pin hole in the line, about 2” down after the bend in the plastic. How …Amazon announced that it would be levying a 5% fuel and inflation fee on online merchants that use its shipping services. Amazon announced that it would be levying a 5% fuel and in... baxter theatre louisville ky showtimes May 31, 2008 · 1855 posts · Joined 2008. #5 · Jun 2, 2008. I just found out that the typical "fuel line hose" is now different, and you need special "fuel injection" fuel line hose. I use to pay 55 cents per foot for the old stuff, but today I paid nearly $9.00 for 2 feet of the f/i hose. I guess the PSI is quite a bit different (15 PSI vs 70 PSI), at least ... 137 posts · Joined 2013. #1 · Apr 15, 2014. Have been chasing a P0442 code and have changed out any suspect rubber lines and added hose clamps where needed as well as replacing the gas cap. I have noticed that my very rusty fuel vapor return line looks to have a few small seeps, showing wet spots on the line in the same consistent places. jason aldean files lawsuit 41703. Comon guys YJ's use a return line, TJ's do not. Most of the manufactures switched at the OBD1/OBD11 transition. I own a 93 YJ and a 99TJ, YJ's have a regulator on at the fuel rail with the return going back to the tank and TJ's have a single feed line with all regulation in the tank as part of the sending unit. g037 vs m367 A lot of people have switched it to the route that you have shown because the gas runs cooler going under rather than over. Mine is sheathed in 5/8" heater hose to insulate the fuel line and prevent the gas from vapor locking. '87 YJ, 4.2L built and bored, 8" of lift, 8.8 rear, AX15/NP 231J, Tom Woods drive shafts, Flat fenders, 12,000LB winch ... crumbl woodmore town center MikeyinaYJ. 255 posts · Joined 2014. #2 · Jul 23, 2014. You could remove it and blow air through it or test fuel pressure, should be a high reading if blocked around 70 I believe. ----------------------------------------. 1994 jeep wrangler 2.5l. Like.1994 Jeep YJ Parts: Fuel Return Line | Classic Tube . Contract Manufacturing. Retail. 1-800-882-3711. Made In The USA. Account Cart. Toggle navigation. Search By Vehicle ... Fuel Return Line (0) Reviews: Write first review. SKU: JER1010-SS. Pricing: $69.99. Qty: Add to Cart Add to Wishlist. Item Inquiry. Description; tokyo express in commerce Hi Moses, Ironically the first thing I did was to replace the fuel filter, assuming that it was restricted to the carburetor. After finding the gas tank vent line clogged I deducted that all the extra pressure from gasoline vapors was traveling backwards to the filter throught the return line, then the vapor lock occurred.1994 Jeep YJ Parts: Fuel Return Line | Classic Tube . Contract Manufacturing. Retail. 1-800-882-3711. Made In The USA. Account Cart. Toggle navigation. Search By Vehicle ... Fuel Return Line (0) Reviews: Write first review. SKU: JER1010-SS. Pricing: $69.99. Qty: Add to Cart Add to Wishlist. Item Inquiry. Description; abcya 3 games Replacement Fuel Lines for 1994 Jeep Wrangler: Products – Inline Tube. 86 CJ7- 304V8,Holley Truck Avenger carb,T5 with D300. D44 with TracLok,3.31 gears, 4" lift. 33x12.5/15 KO2's, Painless Wiring, SpeedHut gauges. You never know the value of a moment until it becomes a memory, Diane M Reynolds 1960-2022. Share.OMIX Front Fuel Supply Line for 94-98 Jeep Cherokee XJ, Grand Cherokee ZJ & Wrangler YJ with 4.0L Engine. In Stock. $52.99. 4.5 (4) ... Classic Tube Fuel Return Line for 1994 Jeep Wrangler YJ with 20 Gallon Fuel Tank. Ships from 3rd Party. $79.99. Classic Tube Fuel Vapor Line for 1989 Jeep Wrangler YJ with 4.2L.Wandering can be caused by a single problematic source in your Jeep's steering, suspension, tires, or brakes. Some vehicles can wander so bad that it actually causes a pulling sens... ascension perks tier list 13 Mar 2013 ... Do any of you have a good picture of a return line setup on an amc v8? Is it 1/4"? Is it rubber all the way from filter to tank? hotels near murfreesboro pike nashville tn 3 Jun 2023 ... ... return fuel to the right tank when the right pump in on. ... TOE THE LINE! - Fuel Supply & Return System ... We SPRAY PAINTED My Jeep Wrangler! tradovate es margin Which fuel line is the return line? Is it the one the routes under the oil pan and then hooks to the hard line on the frame rail under the engine mount??? Or is it the other one???/ hearts of fire tattoo springfield Jul 12, 2017 · You can replace them with bulk FI hose and good hose clamps. If you are replacing the hard lines, you can use a flaring tool to put a little bubble flare on the ends of the lines to give a good grip on the rubber hose/clamps. Same with the vapor hard line. Nothing special. '91 YJ Sahara 4.0L/AX-15/NP231, D30/D35 @3.07. The Q uadratec ® Difference. Includes Phone Tech Support For the life of the product. Satisfaction Guaranteed No hassle return policy. Guaranteed Lowest Price We'll match or beat any price*. Free Shipping Free shipping on orders over $99**. Fuel Supply Line. Quadratec Part #: 51315-1029. Classic Tube Part #: JEF1021-SS. 0.Price wise: $8-10 for each connector and another $2-3 per foot of hose and $1 per FI connector. . Option B-2: Just the hose. Technically if you're crafty and/or grease it up first, you can get a 5/16" hose over the disconnect fittings and just put a hose clamp on both sides of it to secure it.